The purpose of developing advanced in-pit crushing and conveying technology for deep open pits
A.G. Zhuravlev, A.V. Semenkin, V.A. Cherepanov, I.A. Glebov, M.A. Chendyrev
Institute of Mining of Ural Branch of RAS, Ekaterinburg, Russian Federation
Russian Mining Industry №1S / 2022 р. 53-62
Abstract: The development of open pits, both in terms of their mining intensity and a significant increase in the current and design depth, requires improvement of transport systems that form the bulk of the production cost. One of the most proven types of combined transport that provides high productivity is the truck-and-conveyor system. Therefore, this paper focuses on its adaptation to the future mining conditions (high dynamics of open pit mining development with creation of deep quarries, the need to reach open pit depths of up to 800–1200 m). The field of application of different types of transport is not static and changes along with the technical development of transport means, their introduction into mass production, and a change in the target group of mining and operating conditions. The article provides a systematization of open-pit transport applicable in modern conditions and shows the experience gained by the Institute of Mining of Ural branch of RAS in the in-pit crushing and conveying technology, mobile (semi-stationary) crushing and reloading plants and self-propelled crushing units. The results of calculations and technical and economic parameters of open-pit truck haulage and conveyor transport in a wide range of mining conditions are described. It is shown that an urgent research and engineering challenge is the development of technologies for the phased introduction of high-performance equipment for in-pit crushing and conveying transport to a great depth with a minimal additional extension of the open pit walls. At the same time, it is possible to use both steeply inclined and traditional belt conveyors, depending on the specific operating conditions. Conveyor transport is preferable for use at the main stage of the life cycle of deep quarries in terms of its efficiency and throughput, but its use is constrained by a number of factors considered in the paper.
Keywords: in-pit crushing and conveying technology, deep quarry, conveyor, mobile crusher, quarry transport, crusher
Acknowledgments: Studies carried out according to the State Task No.075-00412-22 PR. Topic 1. FUWE-2022-0005.
For citation: Zhuravlev A.G., Semenkin A.V., Cherepanov V.A., Glebov I.A., Chendyrev M.A. The purpose of developing advanced in-pit crushing and conveying technology for deep open pits. Gornaya promyshlennost = Russian Mining Industry. 2022;(1 Suppl.): 53–62. DOI: 10.30686/1609-9192-2022-1S-53-62.
Article info
Received: 10.10.2021
Revised: 25.10.2021
Accepted: 26.10.2021
Information about the authors
Artem G. Zhuravlev – Cand. Sc. (Eng), Laboratory Chief, Institute of Mining of Ural Branch of RAS, Ekaterinburg, Russian Federation; e-mail: This email address is being protected from spambots. You need JavaScript enabled to view it.
Aleksandr V. Semenkin – Junior Research Fellow, Institute of Mining of Ural Branch of RAS, Ekaterinburg, Russian Federation
Vladimir A. Cherepanov – Scientific Researcher, Institute of Mining of Ural Branch of RAS, Ekaterinburg, Russian Federation; e-mail: This email address is being protected from spambots. You need JavaScript enabled to view it.
Igor A. Glebov – Junior Research Fellow, Institute of Mining of Ural Branch of RAS, Ekaterinburg, Russian Federation; e-mail: This email address is being protected from spambots. You need JavaScript enabled to view it.
Mikhail A. Chendyrev – Junior Research Fellow, Institute of Mining of Ural Branch of RAS, Ekaterinburg, Russian Federation; e-mail: This email address is being protected from spambots. You need JavaScript enabled to view it.
References
1. Chendyrev M.A., Zhuravlev A.G. The Technical and Economic Parameters of the Transportation of the Mined Rock from the Open Pit Using the Inclined Automotive Open-Pit Elevator. Ferrous Metallurgy. Bulletin of Scientific, Technical and Economic Information. 2018;1(1):33–36. (In Russ.) Available at: https://chermetinfo.elpub.ru/jour/article/view/829?locale=ru_RU
2. Nel B., Pretorius A. IBR underground mining conference Phakisa mine. Rail-veyor; 2013. 51 p. Available at: https://www.harmony.co.za/ invest/presentations/2013/send/81-2013/522-ibr-underground-mining-conference
3. Cherepanov V.A., Glebov I.A. Factors influencing the opening scheme deep horizons of quarries with the use of sloping underground transport development. MIAB. Mining Inf. Anal. Bull. 2020;(3-1):351–367. (In Russ.) https://doi.org/10.25018/0236-1493-2020-31-0-351-367
4. Yakovlev V.L. The study of transition processes is a new direction in the development of the methodology of integrated development of geo-resources. Ekaterinburg: Institute of Mining of Ural Branch of RAS; 2019 284 p. (In Russ.)
5. Akishev A. N., Bokiy I. B., Zyryanov I. V. On the development of geotechnology for open-cast mining diamond deposits. In: Chemezov E.N. (ed.) Improvement of mining technologies and training of personnel for technosphere safety in conditions of the North-East Russia, Proceedings of the All-Russian Scientific and Practical Conference with international participation devoted to 80th anniversary of EgorChemezov, Doctor of Technique, Professor, full member of Mining Academy, Yakutsk, 25 April 2018. Yakutsk: North-Eastern Federal University named after M.K. Ammosova; 2018, pp. 267–274. (In Russ.)
6. Osanloo M., In-pit crushing and conveying technology in open-pit mining operations: a literature review and research agenda. International Journal of Mining, Reclamation and Environment. 2020;34(6):430–457. https://doi.org/10.1080/17480930.2019.1565054
7. Argimbaev K.R., Maya B.O. The experience of the introduction of mobile crushing and screening complexes on a deposit of building materials. Research Journal of Applied Science. 2016;11(6):300–303. Available at: https://medwelljournals.com/abstract/?doi=rjas ci.2016.300.303
8. Fisher T. Stationary and semi-mobile crushing plants – a comparison: Theoretical considerations. Cement International. 2017;15(4): 66–69.
9. Abbaspour H., Drebenshtedt C., Parisheh M., Ritter R. Optimum location and relocation plan of semi-mobile in-pit crushing and conveying systems in open-pit mines by transportation problem. International Journal of Mining Reclamation and Environment. 2019;33(5):297–317. https://doi.org/10.1080/17480930.2018.1435968
10. Annakulov T.J., Zairov Sh.Sh., Kuvondikov O.A. Justification, selection and calculation of technological parameters of equipment kits of mobile crushing-reloading-conveyor complexes. International Journal of Advanced Research in Science, Engineering and Technology. 2019;6(2):8072–8079. Available at: http://ijarset.com/upload/2019/february/11-IJARSET-Sohib-1.pdf
11. Paricheh M., Osanloo M., Rahmanpour M. In-pit crusher location as a dynamic location problem. Journal of the Southern African Institute of Mining and Metallurgy. 2017;117(6):599–607. https://doi.org/10.17159/2411-9717/2017/V117N6A11
12. Volotkovsky V.S., Karmaev G.D., Draya M.I. Selection of equipment for quarry conveyor transport. Moscow: Nedra; 1990. 192 p. Ё (In Russ.)
13. Gruzdev A.V., Osadchy A.M.1, Furin V.O. Stationary and transportable crushing-handling plants manufactured by Uralmashplant. Gornaya promyshlennost = Russian Mining Industry. 2012;(4):98–104. (In Russ.) Available at: https://mining-media.ru/ru/article/ drobilka/8223-statsionarnye-i-polustatsionarnye-drobilno-peregruzochnye-ustanovki-oao-uralmashzavod
14. Karmaev G.D., Glebov A.V. Selection of mining and transport equipment for cyclic-flow technology of quarries. Ekaterinburg: Institute of Mining of Ural Branch of RAS; 2012. 296 p. (In Russ.)
15. Lukichev S.V., Nagovitsyn O.V. Digital simulation in solving problems of surface and underground mining technologies. Gornyi Zhurnal. 2019;(6):51–55. https://doi.org/10.17580/gzh.2019.06.06
16. Bakhturin Yu.A., Zhuravlev A.G., Trofimenko L.A. Certificate of state registration of a computer program. 2012617844 Russian Federation. Quarry Transport System (QTS). 2012615505; application 03.07.12; publ. 30.08.12. (In Russ.)
17. Sytenkov V.N., Bychikhina D.A. Calculation of a feasible mining depth for the introduction of cyclic-continuous technology for solid mineral deposit development. Ratsionalnoe osvoenie nedr = Mineral Mining & Conservation. 2014;(1):30–33. (In Russ.)
18. Atakulov L.N., Sheshko O.E. Improvement of economic efficiency of the high-angle conveyor knk-270 at Navoi mining and metallurgical combinat. MIAB. Mining Inf. Anal. Bull. 2019;(5):181–188. (In Russ.) https://doi.org/10.25018/0236-1493-2019-05-0-181-188
19. Makarova A.S., Telegina O.V. Installation prospects and characterization of steep angle conveyor belt at mikhailovsky mining and processing plant. MIAB. Mining Inf. Anal. Bull. 2018;(5):178–183. (In Russ.) https://doi.org/10.25018/0236-1493-2018-5-0-178-183
20. Yakovlev V.L., Bersenev V.A., Glebov A.V., Kulniyaz S.S., Marinin M.A. Selecting cyclical-and-continuous process flow diagrams for deep open pit mines. Journal of Mining Science. 2019;55(5):783–788. https://doi.org/10.1134/S106273911905615X
21. Bersenev V.A., Karmayev G.D., Semenkin A.V., Sumina I.G. Schemes of cyclic-flow technology by various bedding of mineral deposits (Reviewing of existing and proposed schemes of CFT) Problemy nedropolzovaniya. 2018;(4):13–21. (In Russ.) Available at: https://trud.igduran.ru/edition/19/2
22. Akishev A.N., Zyryanov I.V., Shubin G.V., Tarasov P.I., Zhuravlev A.G. Technical and engineering complex for the reserves improvement on the deep horizons of diamondiferous open pits. Gornyi Zhurnal. 2012;(12):39–43. (In Russ.) Available at: https://www.rudmet.ru/journal/989/article/15632/
23. Zyryanov I.V., Akishev A.N., Bokiy I.B., Bondarenko I.F. Innovations in diamond mine planning in a permafrost zone. Gornaya promyshlennost = Russian Mining Industry. 2018;(5):66–69. (In Russ.) https://doi.org/10.30686/1609-9192-2018-5-141-66-69
